TM-55-4920-226-15

• ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT, AND DEPOT MAINTENANCE MANUAL WITH REPAIR PARTS AND SPECIAL
• SAFETY PRECAUTIONS
• TEST STAND, AIRCRAFT, HYDRAULIC
• Table of Contents
• Table of Contents (Cont)
• Chapter 1. INTRODUCTION
• Figure 1. Aircraft hydraulic test stand, three-quarter, right front view.
• Figure 2. Aircraft hydraulic test stand, three-quarter, left rear view.
• Tabulated Data
• Figure 5. Shipping dimensions.
• Figure 6. Schematic Hydraulic Diagram
• Inspection of New Equipment
• Figure 8. Aircraft hydraulic test stand, left side view.
• Section II. CONTROLS AND INSTRUMENTS
• Starter Switch
• Oil Pressure Gage
• Filter Pressure Gage
• Stopping the Test Stand
• Section IV. OPERATION UNDER UNUSUAL CONDITIONS
• Chapter 3. OPERATOR AND ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Figure 11. Oil filter, air cleaner, and ignition magneto, installed view.
• Section III. PREVENTIVE MAINTENANCE SERVICES
• Section IV. TROUBLESHOOTING
• Engine Knocks or Develops Excessive Noise
• Section V. HYDRAULIC SYSTEM
• Bleeding Air From the Hydraulic System
• Figure 13. Filter and manifold assembly, exploded view
• Hose Assemblies
• Section VI. RUNNING GEAR ASSEMBLY
• Figure 14. Continued
• Figure 15. Brake lever assembly,exploded view
• Drawbar and Steering Arm Assemblies
• Installation.
• Chapter 4. DIRECT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
• Direct and General Support Preventive Maintenance Services
• Section ill. TROUBLESHOOTING
• Engine Overheats
• Tire Wear Abnormal or Uneven
• General Sources of Interference
• Interference Suppression Components
• Section V. REMOVAL AND INSTALLATION OF MAJOR COMPONENTS
• Engine
• Figure 18. Engine and fuel tank, removal points
• Figure 18. Engine and fuel tank, removal points (Cont)
• Chapter 5. ENGINE MAINTENANCE INSTRUCTIONS
• Engine Accessory Generator
• Figure 19. Engine accessory generator, exploded view
• Electrical Engine Starter
• Figure 20. Electrical engine starter, exploded view
• Spark Plugs and Cables
• Figure 21. Ignition magneto, exploded view
• Cleaning, Inspection, and Repair.
• Reassembly.
• Section Il. AIR SHROUDING GROUP
• Figure 23. Air shrouding group, exploded view
• Cylinder Shrouds and Heat Deflectors
• Section III. MANIFOLD AND CYLINDER BLOCK GROUP
• Carburetor
• Figure 24. Manifold and crankase group, removal points
• Intake and Exhaust Manifold
• Figure 25. Carburetor, exploded view
• Cylinder Heads
• Figire 26. Cylinder block assembly, exploded view
• Section IV. OIL FILLER AND FILTER MOUNTING GROUP
• Section V. FUEL PUMP, FUEL STRAINER AND FUEL TANK
• Fuel Pump and Adapter
• Figure 27. Camshaft and fuel pump mounting group, removal points
• Figure 28. Fuel pump, exploded view
• Fuel Tank
• Figure 29. Gevernor and control asssembly, exploded view
• Governor
• Cleaning, Inspection, and Repair.
• Section VII. ENGINE CONTROLS AND INSTRUMENTS
• Engine Controls
• Chapter 6. HYDRAULIC SYSTEM MAINTENANCE INSTRUCTIONS
• Figure 30. Reservoir, exploded view
• Section Il. FILTERS AND MANIFOLD ASSEMBLY
• High Pressure Filter
• Section Ill. HYDRAULIC SYSTEM INSTRUMENTS
• Section IV. CONTROL VALVES AND PANEL
• Figure 31. High pressure relief valve, epxloded view
• Flow Control, Gage Snubber, Fluid Bypass and Reservoir Shutoff Valves
• Section V. HYDRAULIC PUMP
• Disassembly
• Chapter 7. HOUSING AND RUNNING GEAR MAINTENANCE  INSTRUCTIONS
• Figure 32. Housing assembly, exploded view
• Reassembly and Installation
• Axles and Steering Tie Rods
• Removal and Disassembly.
• Section III. HANDBRAKE ASSEMBLY
• Section IV. FRAME ASSEMBLY
• Arm and Support Assemblies
• Chapter 8. DEPOT MAINTENANCE INSTRUCTIONS
• Ammeter Shows No Charge or Discharge With Engine Operating
• Chapter 9. ENGINE MAINTENANCE INSTRUCTIONS
• Figure 33. Engine generator regulator, exploded view
• Air Gap Adjustment.
• Engine Accessory Generator
• Electrical Engine Starter
• Cleaning, Inspection, and Repair.
• Ignition Magneto
• Section Il. CYLINDER BLOCK GROUP
• Valve Seat Inserts and Valve Guides
• Section III. GEAR COVER AND TIMING GEARS
• Timing Gears
• Section IV. CRANKCASE BOTTOM PLATE AND OIL PUMP
• Oil Pump
• Section V. CRANKSHAFT AND CAMSHAFT GROUP
• Connecting Rod and Piston
• Cleaning, Inspection, and Repair.
• Crankshaft
• Section VI. CYLINDER BLOCKS AND CRANKCASE
• Crankcase
• Chapter 10. HYDRAULIC SYSTEM AND RUNNING GEAR MAINTENANCE INSTRUCTIONS
• Figure 37. Pump, exploded view
• Cleaning, Inspection, and Repair
• Figure 38. Pressure compensator control, exploded view
• Section II. HYDRAULIC PUMP
• Figure 39. Hanger housing assembly, exploded view
• Cleaning, Inspection, and Repair
• Section Ill. FRAME ASSEMBLY
• CHAPTER 11 SHIPMENT AND LIMITED STORAGE AND DEMOLITION OF MATERIAL TO PREVENT ENEMY USE
• Other Demolition Methods
• APPENIDX I REFERENCES
• APPENDIX II MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Appendix III: REPAIR PARTS LIST
• Federal Supply Code for Manufacturers
• Federal Supply Code for Manufacturers (Cont)
• Section II: Group Assembly Parts List Controls and Intsruments
• Section II: Group Assembly Parts List Controls and Intsruments (Cont)
• Section II: Engine Control Panel
• Section II: Engine Control Panel (Cont)
• Section II: Engine Control Panel (Cont)
• Section II: Engine Control Panel (Cont)
• Section II: Filter and Manifold Assembly
• Section II: Filter and Manifold Assembly (Cont)
• Section II: Running Gear and Brake Assembly
• Section II: Running Gear and Brake Assembly (Cont)
• Section II: Running Gear and Brake Assembly (Cont)
• Section II: Running Gear and Brake Assembly (Cont)
• Section II: Running Gear and Brake Assembly (Cont)
• Section II: Running Gear and Brake Assembly (Cont)
• Section II: Brake Lever Assembly
• Section II:Generator and Radio Suppression Capacitor
• Section II: Electrical Installation
• Section II: Electrical Installation (Cont)
• Section II: Electrical Installation (Cont)
• Section II: Engine and Fuel Tank
• Section II: Engine and Fuel Tank (cont)
• Section II: Engine Accessory Generator
• Section II: Engine Accessory Generator (Cont)
• Section II: Engine Accessory Generator (Cont)
• Section II: Electrical Engine Starter
• Section II: Electrical Engine Starter (Cont)
• Section II: Ignition Magneto
• Section II: Ignition Magneto (Cont)
• Section II: Ignition Magneto (Cont)
• Section II: Ignition Magneto (Cont)
• Section II: Air Shoulding Group
• Section II: Manifold and Crankase Group
• Section II: Manifold and Crankase Group (Cont)
• Section II: Carburetor
• Section II: Carburetor (Cont)
• Section II: Cylinder Block Assembly
• Section II: Camshaft and Fuel Pump Mounting Group
• Section II: Camshaft and Fuel Pump Mounting Group (Cont)
• Section II: Fuel Pump
• Section II: Fuel Pump (Cont)
• Section II: Governor and Control Assembly
• Section II: Governor and Control Assembly (Cont)
• Section II: Governor and Control Assembly (Cont)
• Section II: Reservoir
• Section II: Reservoir (Cont)
• Section II: Housing Assembly
• Section II: Housing Assembly (Cont)
• Section II: Housing Assembly (Cont)
• Section II: Housing Assembly (Cont)
• Section II: Housing Assembly (Cont)
• Section II: Engine Generator Regulator
• Section II: Gear Cover Group
• Section II: Oil Pump Assembly
• Section II: Crankshaft, Piston and Connecting Rod Group
• Section II: Crankshaft, Piston and Connecting Rod Group (Cont)
• Section II: Crankshaft, Piston and Connecting Rod Group (Cont)
• Section II: Pump
• Section II: Pump (Cont)
• Section II: Pump (Cont)
• Section II: Pressure Compensator Control
• Section II: Pressure Compensator Control (Cont)
• Section II: Pressure Compensator Control (Cont)
• Section II: Hanger Housing Assembly
• Section II: Hanger Housing Assembly (Cont)
• Section II: Requisition By Part Number, Items Not Assigned FSN
• Section II: Requisition By Part Number, Items Not Assigned FSN (Cont)
• Section II: Requisition By Part Number, Items Not Assigned FSN (Cont)
• Section II: Requisition By Part Number, Items Not Assigned FSN (Cont)
• Section II: Requisition By Part Number, Items Not Assigned FSN (Cont)
• Section II: Requisition By Part Number, Items Not Assigned FSN (Cont)
• Section III: Numerical Index - part I
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part I (Cont)
• Section III: Numerical Index - part II
• Section III: Numerical Index - part II (Cont)
• Section III: Numerical Index - part II (Cont)
• Section III: Numerical Index - part II (Cont)
• Section III: Numerical Index - part II (Cont)
• INDEX
• INDEX (Cont)
• INDEX (Cont)
• TM-55-4920-226-15
• Shared Top Border
• Blank Page
• By Order of the Secretary of the Army:
• Shared Bottom Border
• Blank Page
• Blank Page
• Shared Left Border
• Blank Page

Privacy Statement - Press Release - Copyright Information. - Contact Us